Hino Workshop Manual 700 Series FS1E, FY1E, SH1E, SR1E, SS1E with E13C (S1-HSSE02K) ALGERIA, CHILE, SINGAPORE, SOUTH AFRICA, THAILAND :

This Hino workshop manual has been prepared to provide information regarding repair procedures on Hino Trucks.
Applicable for HINO FS1E, FY1E, SH1E, SS1E with E13C series.
When making any repairs on your vehicle, be careful not to be injured through improper procedures.
As for maintenance items, refer to the Owner’s Manual.
All information and specifications in this manual are based upon the latest product information available at the time of printing.
Hino Motors reserves the right to make changes at any time without prior notice.

This manual is divided into 11 sections with a thumb index for each section at the edge of the pages.
Please note that the publications below have also been prepared as relevant service manuals for the components and systems in this vehicles.

Chassis Workshop Manual S1-HSSE02F
Chassis Workshop Manual S1-HFSE06A

FOREWORD
GENERAL INTRODUCTION
CLUTCH MAIN UNIT (EATON EP2000)
CLUTCH MAIN UNIT (DSP430)
CLUTCH CONTROL(EATON EP2000)
CLUTCH CONTROL(DSP430)
TRANSMISSION MAIN UNIT(FULLER RTLO18918B)
TRANSMISSION MAIN UNIT (ZF16S221)
TRANSMISSION/TRANSFER CONTROL
PROPELLER SHAFT (GWB2065)
PROPELLER SHAFT (HD0000)
DIFFERENTIAL EQUIPMENT(LOKING TYPE DIFFERENTIAL GEAR: NO SPIN)
DIFFERENTIAL EQUIPMENT(LOKING TYPE DIFFERENTIAL GERE:MANUAL TYPE)
DIFFERENTIAL CARRIER(SH18)
DIFFERENTIAL CARRIER(THD18)
BRAKE EQUIPMENT
SERVICE BRAKE
ABS&ASR(WABCO)
STEERING EQUIPMENT
STEERING UNIT
POWER STEERING
FRONT AXLE(ISO 10-STUDS TYPE)
REAR AXLE (WITH ISO TYPE WHEEL)
WHEEL&TIRE
SUSPENSION(FRONT)
SUSPENSION (HENDRICKSON HAS 460)
CHASSIS FRAME
COUPLER (5TH WHEEL)
CAB
ELECTRICAL EQUIPMENT
BRAKE CONTROL(ABS: WABCO)
OTHERS(CAN COMMUNICATION)
FOREWORD
ELECTRIC WIRE
FOREWORD
GENERAL INTRODUCTION
ENGINE INTRODUCTION (E13C)
ENGINE MECHANICAL (E13C)
AIR INTAKE SYSTEM (E13C)
EXHAUST SYSTEM (E13C)
LUBRICATING SYSTEM (E13C)
COOLING SYSTEM (E13C)
FUEL SYSTEM (E13C)
TURBOCHARGER (E13C: ELECTRIC VGT)
TURBOCHARGER (E13C: PNEUMATIC VGT)
EMISSION CONTROL
ALTERNATOR (E13C: 24V-90A)
ALTERNATOR (E13C: 24V-90A)
STARTER (E13C)
AIR COMPRESSOR (E13C: 340 cm3 TYPE)
AIR COMPRESSOR (E13C: 496 cm3 TYPE)
ENGINE P.T.O. (POWER TAKE-OFF) (E13C)
ENGINE RETARDER (E13C)
FUEL CONTROL (E13C: WITH EGR)
FUEL CONTROL (E13C: WITHOUT EGR)